2018 FORD F 550 SD Official Safety Recalls
Source: National Highway Traffic Safety Administration (NHTSA)
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
SEAT BELTS:PRETENSIONER
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
A vehicle fire could result if materials ignite inside the vehicle.
Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
EQUIPMENT
Farber Specialty Vehicles (Farber) is recalling certain 2018 Ford F-550 vehicles equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affected monitors may revert back to the factory default settings which can cause the camera image to be reversed.
The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Farber will notify owners, and dealers will add a harness relay capacitor module, free of charge. The recall began May 9, 2019. Owners may contact Farber customer service at 1-800-331-3188 or ASA customer service at 1-800-384-4400.
EQUIPMENT
VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.
EQUIPMENT
LGE Coachworks, Inc. (LGE Coachworks) is recalling certain 2018-2019 Ford E-450, F-550, and Freightliner M2-based vehicles equipped with ASA Electronics Voyager back-up camera displays. The displays may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
ASA will notify LGE Coachworks owners, and dealers will replace the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA customer service at 1-800-384-4400 or LGE Coachworks at 1-800-209-3985.
EXTERIOR LIGHTING:BRAKE LIGHTS
Unruh Fire, Inc. (Unruh Fire) is recalling certain 2017-2018 Ford F-550-based fire trucks equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Unruh Fire has notified owners and will replace the brake lights, free of charge. The recall began in May 20, 2019. Owners may contact Unruh Fire customer service at 1-800-856-7080.
EXTERIOR LIGHTING:BRAKE LIGHTS
Taylor Made Ambulances is recalling certain 2017-2018 Ford E-350, F-450, E-450, F-550, and GMC G3500-based ambulances equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Taylor Made will notify owners and Whelen will replace the brake lights, free of charge. The recall began June 5, 2019. Owners may contact Taylor Made Ambulances customer service at 1-800-468-1310.
ENGINE
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
EXTERIOR LIGHTING:BRAKE LIGHTS
Weis Fire & Safety is recalling one 2018 Emergency vehicle built on a Ford F-550 4x4 Crew Cab chassis and equipped with Whelen brake lights recalled under 18E-063. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Weis Fire & Safety has already notified the owner, and replaced the brake lights, free of charge. The recall began October 1, 2018. Owners may contact Weis Fire & Safety customer service at 1-785-825-9526.
EXTERIOR LIGHTING:BRAKE LIGHTS
Blanchat Mfg., Inc. (Blanchat) is recalling one 2018 B-27 Minuteman vehicle built on a Ford F-550 chassis and equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Blanchat has notified the owner, and will replace the brake lights, free of charge. The recall began on March 27, 2019. Owners may contact Blanchat customer service at 1-620-896-7145.
EXTERIOR LIGHTING:BRAKE LIGHTS
Fire Equipment Sales & Service (FES) is recalling one Super C Brush emergency vehicle and one Tanker emergency vehicle equipped with Whelen brake lights recalled under 18E-063. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
FES has already notified owners, and replaced the brake lights, free of charge. Owners may contact FES customer service at 1-803-494-6000 or Whelen customer service at 1-860-718-2331.
EXTERIOR LIGHTING:BRAKE LIGHTS
Excellance, Inc. (Excellance) is recalling certain 2018 Ambulances and Emergency Vehicles built on Ford E-350, E-450, F-650, F-550 4x4, Chevrolet G4500, G4500 Diesel, C3500, G3500, Freightliner M2, International 4300, and Dodge 4500 chassis and equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Excellance has notified owners, instructing them to contact Whelen to have the brake lights replaced, free of charge. The recall began on March 21, 2019. Owners may contact Whelen customer service at 1-860-718-2331 or Execellance at 1-256-772-9321.
ENGINE
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
FORD F 550 SD Recalls by Model Year
13 Years AvailableSelect a production year to inspect official manufacturer defect notices and safety recall bulletins: